install a/c on 76 scottsdale - The 1947 - Present Chevrolet & GMC Truck Message Board Network

HotRodScottsdale · 08-28-2011, 02:52 AM

so something hit me when i was enjoying a round of hits from the bong with buddys stairing at my truck when we relized... my summer truck only has heat in it and that isnt desireable when in traffic.plus the fact i need to redo my rad and cooling system as the hose keeps falling off the block no matter what i do(thinking the connector or somethings messed up ) so i figured would it be worth it to put a/c in too, i can post pics of anything needed for people to give me info..

67_SS396 · 08-28-2011, 03:10 AM

A/c is nice here in the south. Have you tried to tighten the lower radiator hose? May need to put the bong down first though...
Posted via Mobile Device

HotRodScottsdale · 08-28-2011, 03:13 AM

i have, so tight its splitting the hose, so i got a new hose and a new clamp and same problem, its super tght but slips right off with a slight push

**hatzie** · 08-28-2011, 09:55 AM

There should be a bead at the top of the cast fitting that keeps the hose from slipping past. The upper fitting can be replaced by itself along with the thermostat. The lower hose fitting is a cast part of the water pump you'll need to replace the whole water pump.

Adding AC isn't a cheap weekend project. R12 & R134 is pretty tightly controlled in Canada. Adding AC to a non AC truck means cutting and welding a panel into the firewall from a donor cab. You'll need the compressor, brackets, condenser, hoses, evaporator, heater box, AC/Heater wiring, and controls from a donor too... It's not a cheap proposition to add AC.

BTW Lake Okanangan is a gorgeous area of BC.

donut · 08-28-2011, 10:32 AM

Like hatzie mentioned, there should be a lip on the water pump. If you've had a slow leak it may have caked up with gunk. Scrape, file, clean however you like to expose this lip.

Does it look like the oil/coolant are mixing? If the hose keeps "popping off" this could indicate a deeper problem where your cooling system is over-pressurizing and the hose connection is the weak link.

Zane M · 08-28-2011, 10:50 AM

As far as AC goes, unless you need the truck to look factory correct, I would suggest going with a Vintage Air system.

lilpoindexter · 08-28-2011, 02:46 PM

Pass the bong to the left

**old Rusty C10** · 08-28-2011, 06:03 PM

my newer model 82 cost me several hundred to replace parts of the Air conditioner being the prior owner tried ripping out the system in faor of a hotrod look in the engine bay.. i found that its cheaper to buy air conditioning hoses from a autoparts store than LMC and i was able to find all the brackets in the boneyard otherwise it would have been exceptionally pricey to do this

Moderator note lets refrain from using words that have asterisks in them or other non friendly family vocabularty.. this one was free next time i have to edit it will result in an infraction

Hevy · 08-28-2011, 06:51 PM

Quote:

Originally Posted by 67_SS396

A/c is nice here in the south. Have you tried to tighten the lower radiator hose? May need to put the bong down first though...
Posted via Mobile Device

HotRodScottsdale · 08-28-2011, 08:41 PM

well shes parked till i get a new cooling system/rad and all that jazz,its road eye candy till i get the cash to order all the parts and install

08-28-2011, 02:52 AM	#1
HotRodScottsdale Registered User Join Date: Sep 2009 Location: westbank bc Posts: 239	install a/c on 76 scottsdale so something hit me when i was enjoying a round of hits from the bong with buddys stairing at my truck when we relized... my summer truck only has heat in it and that isnt desireable when in traffic.plus the fact i need to redo my rad and cooling system as the hose keeps falling off the block no matter what i do(thinking the connector or somethings messed up ) so i figured would it be worth it to put a/c in too, i can post pics of anything needed for people to give me info.. Last edited by old Rusty C10; 08-28-2011 at 06:04 PM.

08-28-2011, 03:10 AM	#2
67_SS396 Registered User Join Date: Mar 2000 Location: Blue Ridge, Tx Posts: 1,172	Re: install a/c on 76 scottsdale A/c is nice here in the south. Have you tried to tighten the lower radiator hose? May need to put the bong down first though... Posted via Mobile Device __________________ Fawker Fab three seater rock crawler buggy 498 BBC/SM465/203/205 doubler, propane, 5.13's, 42" PB Rockers '66 C10 - The new hot rod '77 3+3 Dually - 12 valve 4wd conversion tow rig project '28 Ford 2 door sedan street rod RevLimit Offroad "Hang on beer, we can do this."

08-28-2011, 03:13 AM	#3
HotRodScottsdale Registered User Join Date: Sep 2009 Location: westbank bc Posts: 239	Re: install a/c on 76 scottsdale i have, so tight its splitting the hose, so i got a new hose and a new clamp and same problem, its super tght but slips right off with a slight push

08-28-2011, 09:55 AM	#4
hatzie Moderator Join Date: Oct 2008 Location: Wentworth, NH Posts: 4,977	Re: install a/c on 76 scottsdale There should be a bead at the top of the cast fitting that keeps the hose from slipping past. The upper fitting can be replaced by itself along with the thermostat. The lower hose fitting is a cast part of the water pump you'll need to replace the whole water pump. Adding AC isn't a cheap weekend project. R12 & R134 is pretty tightly controlled in Canada. Adding AC to a non AC truck means cutting and welding a panel into the firewall from a donor cab. You'll need the compressor, brackets, condenser, hoses, evaporator, heater box, AC/Heater wiring, and controls from a donor too... It's not a cheap proposition to add AC. BTW Lake Okanangan is a gorgeous area of BC.

08-28-2011, 10:32 AM	#5
donut Registered User Join Date: Aug 2009 Location: S.C. Posts: 1,593	Re: install a/c on 76 scottsdale Like hatzie mentioned, there should be a lip on the water pump. If you've had a slow leak it may have caked up with gunk. Scrape, file, clean however you like to expose this lip. Does it look like the oil/coolant are mixing? If the hose keeps "popping off" this could indicate a deeper problem where your cooling system is over-pressurizing and the hose connection is the weak link. __________________ '86 C-30 dually, 454/tbh400 '73 K-20 350/350/205 (sold ) I'm kinda like duct tape- no real purpose, but handy to have around.

08-28-2011, 10:50 AM	#6
Zane M Registered User Join Date: Dec 2006 Location: SLC, UT Posts: 706	Re: install a/c on 76 scottsdale As far as AC goes, unless you need the truck to look factory correct, I would suggest going with a Vintage Air system.

08-28-2011, 02:46 PM	#7
lilpoindexter Registered User Join Date: Sep 2010 Location: los angeles Posts: 1,134	Re: install a/c on 76 scottsdale Pass the bong to the left

08-28-2011, 06:03 PM	#8
old Rusty C10 Robert Olson Transport Join Date: Oct 2002 Location: recent transplant to NC USA Posts: 20,310	Re: install a/c on 76 scottsdale my newer model 82 cost me several hundred to replace parts of the Air conditioner being the prior owner tried ripping out the system in faor of a hotrod look in the engine bay.. i found that its cheaper to buy air conditioning hoses from a autoparts store than LMC and i was able to find all the brackets in the boneyard otherwise it would have been exceptionally pricey to do this Moderator note lets refrain from using words that have asterisks in them or other non friendly family vocabularty.. this one was free next time i have to edit it will result in an infraction __________________ Bob 1951 International running on a squarebody chassis "If a man's worth is judged by the people he associates himself with, then i am the richest man in the world knowing some of the fine people of this board" http://67-72chevytrucks.com/vboard/a...t.php?f=25&a=9 (you can review the site rules here!) PM Me for your vehicle/parts hauling needs in the North East US or see my Facebook page Robert Olson Transport Live each day to the fullest.. you never know when fate is going to pull the rug out from under you... I hate cancer!!

08-28-2011, 08:41 PM	#10
HotRodScottsdale Registered User Join Date: Sep 2009 Location: westbank bc Posts: 239	Re: install a/c on 76 scottsdale well shes parked till i get a new cooling system/rad and all that jazz,its road eye candy till i get the cash to order all the parts and install



Register or Log In To remove these advertisements.

Register or Log In To remove these advertisements.